Numerical investigation of the influence of a bearing/shaft structure in an axial blood pump on the potential for device thrombosis

Abstract

Adverse events caused by flow-induced thrombus formation around the bearing/shaft of an axial blood pump remain a serious problem for axial blood pumps. Moreover, excessive anticoagulation with thrombosis around the bearing potentially increases the risk of postoperative gastrointestinal bleeding. The purpose of this study is to analyze the influence of the bearing structure on the thrombosis potential of an axial blood pump. The bearing/shaft structure was embedded into an axial blood pump numerical model. The numerical simulation and analysis are focused on the low wall shear stresses, recirculation, and residence time close to the bearing region to evaluate the potential for thrombosis around the bearing. Then, the flow field near the blood pump bearing was tested via in vitro particle image velocimetry experiments to verify the numerical results. The simulation results showed that after embedding the bearing/shaft structure a recirculation zone appeared in the outlet guide vane bearing/shaft region, the residence time increased 11-fold in comparison to the pump without the bearing/shaft structure, the scalar shear stress in the shaft surface was less than 7.8 Pa, and the stress accumulation was less than 0.10 Pa s. The numerical results showed that platelets that flow through the bearing region are exposed to significantly lower wall shear stress and a longer residence time, leading to activated platelet adhesion. The reduced stress accumulation and increased time in the bearing region lead to increased platelet activation.

Keywords

Axial blood pump thrombus formation numerical simulation residence time shear stress

Get full access to this article

View all access options for this article.

References

Smedira

Blackstone

Ehrlinger

et al . Current risks of HeartMate II pump thrombosis: non-parametric analysis of interagency registry for mechanically assisted circulatory support data. J Heart Lung Transplant 2015; 34(12): 1527–1534.

Mondal

Sorensen

Feller

et al . Comparison of intra platelet reactive oxygen species, mitochondrial damage, and platelet apoptosis after implantation of three continuous flow left ventricular assist devices: HeartMate II, Jarvik 2000, and HeartWare. ASAIO J 2015; 61(3): 244–252.

Molina

Boyce

SW.

Current status of left ventricular assist device technology. Semin Thorac Cardiovasc Surg 2013; 25(1): 56–63.

Ono

Sawa

Nakatani

et al . Japanese multicenter outcomes with the HeartMate II left ventricular assist device in patients with small body surface area. Circ J 2016; 80(9): 1931–1936.

Magruder

Grimm

Crawford

et al . Survival after orthotopic heart transplantation in patients undergoing bridge to transplantation with the HeartWare HVAD versus the HeartMate II. Ann Thorac Surg 2017; 103: 1505–1511.

Graefe

Henseler

Steinseifer

Multivariate assessment of the effect of pump design and pump gap design parameters on blood trauma. Artif Organs 2016; 40(6): 568–576.

Damm

Mizuguchi

Bozeman

In vitro performance of the Baylor/NASA axial flow pump. Artif Organs 1993; 17(7): 609–613.

Mizuguchi

Damm

Benkowsky

Development of an axial flow ventricular assist device: in vitro and in vivo evaluation. Artif Organs 1995; 19(7): 653–659.

Koliopoulou

McKellar

Rondina

et al . Bleeding and thrombosis in chronic ventricular assist device therapy: focus on platelets. Curr Opin Cardiol 2016; 31(3): 299–307.

10.

Pagani

Miller

Russell

et al . Extended mechanical circulatory support with a continuous-flow rotary left ventricular assist device. J Am Coll Cardiol 2009; 54: 312–321.

11.

Girdhar

Xenos

Alemu

et al . Device thrombogenicity emulation: a novel method for optimizing mechanical circulatory support device thromboresistance. PLoS One 2012; 7(3): e32463.

12.

Mokadam

Andrus

Ungerleider

Thrombus formation in a HeartMate II. Eur J Cardiothorac Surg 2011; 39(3): 414.

13.

Najib

Wong

Pierce

et al . An unusual presentation of left ventricular assist device thrombus. Eur Heart J Cardiovasc Imaging 2012; 13(6): 532.

14.

Essandoh

Shabsigh

Turner

et al . HeartMate II inflow path thrombosis: emphasis on a comprehensive approach to diagnosis. J Cardiothorac Vasc Anesth 2017; 31(3): 1015–1020.

15.

Chiu

Slepian

Bluestein

Thrombus formation patterns in the HeartMate II ventricular assist device: clinical observations can be predicted by numerical simulations. ASAIO J 2014; 60(2): 237–240.

16.

Chiu

Girdhar

Xenos

et al . Thromboresistance comparison of the HeartMate II ventricular assist device with the device thrombogenicity emulation-optimized HeartAssist 5 VAD. J Biomech Eng 2014; 136(2): 021014.

17.

Yang

et al . High fidelity computational simulation of thrombus formation in Thoratec HeartMate II continuous flow ventricular assist device. Sci Rep 2016; 6: 38025.

18.

Taylor

Meyer

Deutsch

et al . Development of a computational model for macroscopic predictions of device-induced thrombosis. Biomech Model Mechanobiol 2016; 15(6): 1713–1731.

19.

Liu

Jin

Zhou

et al . Design and numerical evaluation of an axial partial-assist blood pump for Chinese and other heart failure patients. Int J Artif Organs 2017; 40(9): 489–497.

20.

Chua

Lim

et al . Numerical simulation of an axial blood pump. Artif Organs 2007; 31(7): 560–570.

21.

Bludszuweit

Three-dimensional numerical prediction of stress loading of blood particles in a centrifugal pump. Artif Organs 1995; 19(7): 590–596.

22.

Iacovoni

Centofanti

Attisani

et al . Low incidence of gastrointestinal bleeding and pump thrombosis in patients receiving the INCOR LVAD system in the long-term follow-up. Int J Artif Organs 2015; 38(10): 542–547.

23.

Mehra

Naka

Uriel

et al . A fully magnetically levitated circulatory pump for advanced heart failure. N Engl J Med 2017; 376(5): 440–450.

24.

Netuka

Sood

Pya

et al . Fully magnetically levitated left ventricular assist system for treating advanced HF: a multicenter study. J Am Coll Cardiol 2015; 66(23): 2579–2589.

25.

Jabbar

Yau

Frazier

et al . Direct thrombolytic therapy for thrombosis of a centrifugal flow left ventricular assist device. ASAIO J 2013; 59(5): 530–532.

26.

Strueber

O’Driscoll

Jansz

et al . HeartWare investigators: multicenter evaluation of an intrapericardial left ventricular assist system. J Am Coll Cardiol 201112; 57: 1375–1382.

27.

Koksel

Erbasan

Bayezid

et al . Thrombosis in continuous flow left ventricular assist devices: our clinical experience with medical and surgical management. Transplant Proc 2016; 48(6): 2162–2167.