Successful decellularization of thick-walled tissue: Highlighting pitfalls and the need for a multifactorial approach

Abstract

Introduction:

Decellularization of thick tissue is challenging and varying. Therefore, we tried to establish a multifactorial approach for reliable aortic wall decellularization.

Methods:

Porcine aortic walls were decellularized according to different procedures. Decellularization was performed for 24 (G1), 48 (G2), and 72 h (G3) with a solution of 0.5% desoxycholate and 0.5% dodecyl sulfate. The procedure was characterized using intermittent washing steps, the inclusion of sonication as well as DNase and α-galactosidase treatment. The decellularization efficiency was measured by the evaluation of 4′,6-diamidino-2-phenylindole and hematoxylin and eosin staining and quantitative DNA assays. Pentachrome and picrosirius red staining, scanning electron microscopy as well as glycosaminoglycan assays were performed to evaluate the effect of the procedure on the extracellular matrix.

Results:

4′,6-Diamidino-2-phenylindole and hematoxylin and eosin staining revealed a large amount of remaining nuclei in all groups. However, consecutive DNase treatment had a significant effect. While the remaining DNA was detected in some samples of G1 and G2, samples of G3 were fully decellularized. Glycosaminoglycan content was significantly reduced to 50% after 24 h (G1) but remained constant for G2 and G3. Picrosirius red staining revealed an intact and stable collagen network without any visible defects. Pentachrome staining substantiated these results. Nonetheless, the fiber network remains intact, which could be confirmed by reflection electron microscopy analysis.

Conclusion:

In this study, we developed a procedure that grants successful decellularization of porcine aortic wall while maintaining the fibrous microstructure. We highlighted the significant effect of DNase and α-galactosidase treatment. In addition, we could show the need for a multifactorial treatment and comprehensive evaluation protocols for thick tissue decellularization.

Keywords

Decellularization aorta thick tissue galactose-alpha-1,3-galactose DNA

Get full access to this article

View all access options for this article.

References

Gupta

Mishra

NC.

Decellularization methods for scaffold fabrication. Totowa, NJ: Humana Press, 2017, pp. 1–10.

Gilbert

Sellaro

Badylak

SF.

Decellularization of tissues and organs. Biomaterials 2006; 27: 3675–3683.

Keane

Swinehart

Badylak

SF.

Methods of tissue decellularization used for preparation of biologic scaffolds and in vivo relevance. Methods 2015; 84: 25–34.

Crapo

Gilbert

Badylak

SF.

An overview of tissue and whole organ decellularization processes. Biomaterials 2011; 32: 3233–3243.

Gilbert

Freund

Badylak

SF.

Quantification of DNA in biologic scaffold materials. J Surg Res 2009; 152: 135–139.

Mathapati

Verma

Cherian

et al . Inflammatory responses of tissue-engineered xenografts in a clinical scenario. Interact Cardiovasc Thorac Surg 2011; 12: 360–365.

Johnson

Garcia

et al . High short-term failure rate associated with decellularized osteochondral allograft for treatment of knee cartilage lesions. Arthroscopy 2017; 33: 2219–2227.

Dobrilovic

Soukas

Sadiq

et al . Early complications of biologic extracellular matrix patch after use for femoral artery repair. J Vasc Surg 2017; 65: 705–710.

Perri

Polito

Esposito

et al . Early and late failure of tissue-engineered pulmonary valve conduits used for right ventricular outflow tract reconstruction in patients with congenital heart disease. Eur J Cardiothorac Surg 2012; 41: 1320–1325.

10.

Simon

Kasimir

Seebacher

et al . Early failure of the tissue engineered porcine heart valve SYNERGRAFT in pediatric patients. Eur J Cardiothorac Surg 2003; 23: 1002–106.

11.

Kasimir

Rieder

Seebacher

et al . Presence and elimination of the xenoantigen gal (alpha1, 3) gal in tissue-engineered heart valves. Tissue Eng 2005; 11: 1274–1280.

12.

Zheng

Chen

Kirilak

et al . Porcine small intestine submucosa (SIS) is not an acellular collagenous matrix and contains porcine DNA: possible implications in human implantation. J Biomed Mater Res B Appl Biomater 2005; 73: 61–67.

13.

Syed

Walters

Day

et al . Evaluation of decellularization protocols for production of tubular small intestine submucosa scaffolds for use in oesophageal tissue engineering. Acta Biomater 2014; 10: 5043–5054.

14.

Hillebrandt

Polenz

Butter

et al . Procedure for decellularization of rat livers in an oscillating-pressure perfusion device. J Vis Exp 2015; 10: e53029.

15.

González-Andrades

Carriel

Rivera-Izquierdo

et al . Effects of detergent-based protocols on decellularization of corneas with sclerocorneal limbus. Evaluation of regional differences. Transl Vis Sci Technol 2015; 4: 13.

16.

Sierad

Shaw

Bina

et al . Functional heart valve scaffolds obtained by complete decellularization of porcine aortic roots in a novel differential pressure gradient perfusion system. Tissue Eng Part C Methods 2015; 21: 1284–1296.

17.

Cheng

Solorio

Alsberg

Decellularized tissue and cell-derived extracellular matrices as scaffolds for orthopaedic tissue engineering. Biotechnol Adv 2014; 32: 462–484.

18.

O’Connor Mooney

Davis

Hoey

et al . On the automatic decellularisation of porcine aortae: a repeatability study using a non-enzymatic approach. Cells Tissues Organs 2016; 201: 299–318.

19.

Da Costa

Costa

Prestes

et al . The early and midterm function of decellularized aortic valve allografts. Ann Thorac Surg 2010; 90: 1854–1860.

20.

Conconi

De Coppi

Di Liddo

et al . Tracheal matrices, obtained by a detergent-enzymatic method, support in vitro the adhesion of chondrocytes and tracheal epithelial cells. Transpl Int 2005; 18: 727–734.

21.

Starnecker

Köenig

Hagl

et al . Tissue-engineering acellular scaffolds—the significant influence of physical and procedural decellularization factors. J Biomed Mater Res B Appl Biomater 2018; 106: 153–162.

22.

Borges

Taboga

Gutierrez

PS.

Simultaneous observation of collagen and elastin in normal and pathological tissues: analysis of Sirius-red-stained sections by fluorescence microscopy. Cell Tissue Res 2005; 320: 551–552.

23.

Vogel

Siebert

Hofmann

et al . Determination of collagen content within picrosirius red stained paraffin-embedded tissue sections using fluorescence microscopy. MethodsX 2015; 2: 124–134.

24.

Kawecki

Łabuś

Klama-Baryla

et al . A review of decellurization methods caused by an urgent need for quality control of cell-free extracellular matrix’ scaffolds and their role in regenerative medicine. J Biomed Mater Res B Appl Biomater 2018; 106: 909–923.

25.

Roosens

Somers

De Somer

et al . Impact of detergent-based decellularization methods on porcine tissues for heart valve engineering. Ann of Biomed Eng 2016; 44: 2827–2839.

26.

Grauss

Hazekamp

van Vliet

et al . Decellularization of rat aortic valve allografts reduces leaflet destruction and extracellular matrix remodeling. J Thorac Cardiovasc Surg 2003; 126: 2003–2010.

27.

Khalpey

Hemphill

et al . Rapid porcine lung decellularization using a novel organ regenerative control acquisition bioreactor. ASAIO J 2015; 61: 71–77.

28.

Liao

Joyce

Sacks

MS.

Effects of decellularization on the mechanical and structural properties of the porcine aortic valve leaflet. Biomaterials 2008; 29: 1065–1074.

29.

Numata

Fujisato

Niwaya

et al . Immunological and histological evaluation of decellularized allograft in a pig model: comparison with cryopreserved allograft. J Heart Valve Dis 2004; 13: 984–990.

30.

Paniagua Gutierrez

Berry

Korossis

et al . Regenerative potential of low-concentration SDS-decellularized porcine aortic valved conduits in vivo. Tissue Eng Part A 2015; 21: 332–342.

31.

Rosario

Reilly

Ali Salah

et al . Decellularization and sterilization of porcine urinary bladder matrix for tissue engineering in the lower urinary tract. Regen Med 2008; 3: 145–156.

32.

L-C

Kuo

Sun

et al . Optimized decellularization protocol including α-Gal epitope reduction for fabrication of an acellular porcine annulus fibrosus scaffold. Cell Tissue Bank 2017; 18: 383–396.

33.

Schenke-Layland

Vasilevski

Opitz

et al . Impact of decellularization of xenogeneic tissue on extracellular matrix integrity for tissue engineering of heart valves. J Struct Biol 2003; 143: 201–208.

34.

Azhim

Syazwani

Morimoto

et al . The use of sonication treatment to decellularize aortic tissues for preparation of bioscaffolds. J Biomater Appl 2014; 29: 130–141.

35.

Konakci

Bohle

Blumer

et al . Alpha-Gal on bioprostheses: xenograft immune response in cardiac surgery. Eur J Clin Invest 2005; 35: 17–23.

36.

Puga Yung

Borsig

et al . Complete absence of the αGal xenoantigen and isoglobotrihexosylceramide in α1,3galactosyltransferase knock-out pigs. Xenotransplantation 2012; 19: 196–206.

37.

McGregor

Kogelberg

Vlasin

et al . Gal-knockout bioprostheses exhibit less immune stimulation compared to standard biological heart valves. J Heart Valve Dis 2013; 22: 383–390.

38.

Iablonskii

Cebotari

Tudorache

et al . Tissue-engineered mitral valve: morphology and biomechanics. Interact Cardiovasc and Thorac Surg 2015; 20: 712–719.

39.

Uygun

Soto-Gutierrez

Yagi

et al . Organ reengineering through development of a transplantable recellularized liver graft using decellularized liver matrix. Nat Med 2010; 16: 814–820.