Crack Sealing in Flexible Pavements: A Life-Cycle Cost Analysis

Abstract

Pavement cracks are usually sealed to prevent water from entering base course layers. Experience suggests that water in pavement layers hastens pavement deterioration and, therefore, increases rehabilitation costs. Initially the Ministry of Transportation, Ontario (MTO), Canada, had limited success in sealing cracks because inappropriate materials and installation procedures were used. This setback during the initial stages of development in crack sealing raised questions about the effectiveness of crack sealing in reducing the rate of pavement deterioration. In the 1970s and 1980s MTO carried out several field studies to develop an effective crack sealing procedure and to study the influence of crack sealing on pavement distress and performance. The cost-effectiveness of this treatment was investigated as well. The results of the studies indicate that sealing cracks is a viable and cost-effective preventive maintenance treatment and can extend the service life of asphalt pavements by at least 2 years. However, for optimum benefits the crack sealing program must be implemented according to guidelines proposed. The guidelines provide a basis for the selection of suitable pavements and cracks, sealant materials, and application procedures.

Get full access to this article

View all access options for this article.

References

Cedergren

H. R.

, O'Brien

K. H.

, and Arman

J. A.

. Guidelines for the Design of Subsurface Drainage System for Highway Structural Systems. FHWA-TS-86-208. FHWA, U.S. Department of Transportation, July 1986.

Drainable Pavement Systems, Participant Note Book. FWHA-SA-92-108. FHWA, U.S. Department of Transportation, March 1992.

Chong

G. J.

Consequences of Deferred Maintenance Treatment on Transverse Cracks in Cold Regions. Proc., Paving in Cold Areas Mini-Workshop, Ottawa, Ontario, Canada, July 1987, pp. 638–686.

Kingham

R. I.

Cracking of Asphalt Concrete Pavements—A Pilot Study. Parts I, II, and III. Ontario Ministry of Transportation, Canada, 1965.

Crack Sealing: Flexible and Composite Pavements, Maintenance Operating Instruction Manual M-1005-A. Engineering Materials Office, Ministry of Transportation, Ontario, Canada, 1984.

Chong

G. J.

Rout and Seal Cracks in Flexible Pavement: A Cost-Effective Maintenance Procedure. Report PAV-89-04. Research and Development Branch, Ministry of Transportation, Ontario, Canada, Aug. 1989.

Joseph

Field Evaluation of Rout and Seal Treatment in Flexible Pavements. Report PAV-90-03. Research & Development Branch, Ministry of Transportation, Ontario, Canada, 1990.

Jung

F. W.

, Kher

, and Phang

W. A.

. Subsystem for Flexible Pavement Performance Prediction. In Transportation Research Record 572, TRB, National Research Council, Washington, D.C., 1976, pp. 15–28.

Waters

W. G.

II The Value of Time Savings for the Economic Evaluation of Highway Investment in British Columbia. Report for the Planning Service Branch of the British Columbia Ministry of Transportation and Highways, University of British Columbia, Center for Transportation Studies, March 1992.

10.

Hajek

J. J.

, Chong

G. J.

, Haas

R. C. J.

, and Phang

W. A.

. Knowledge-Based Expert System Technology Can Benefit Pavement Maintenance. In Transportation Research Record 1145, TRB, National Research Council, Washington, D.C., 1987, pp. 37–47.

11.

Chong

G. J.

, Phang

W. A.

, and Wrong

W. A.

. Manual for Condition Rating of Flexible Pavements: Distress Manifestations. Report SP-024. Research and Development Branch, Ministry of Transportation, Ontario, Canada, Aug. 1989.