Improvements in High-Speed Ballasted Track Design

Abstract

Track design plays an important role in high-speed rail performance. Increases in high-speed traffic demand and maximum rail speeds will necessitate the development of new, low-maintenance structural solutions for high-speed ballasted tracks. This paper shows that use of tracks with optimum resiliency can reduce railway system operational costs. Use of an alternative to the conventional granular subballast is discussed. The results with Japanese and Italian high-speed lines showing the effectiveness of bituminous subballasts formed the basis for a study focusing on the viability of this option. With Spain used as an example, a theoretical analysis of the characteristics of the bituminous track design is presented. The results of this analysis showed that structural performance was good when a 12-cm to 14-cm conventional bituminous subballast layer was used in lieu of the usual granular layers. Also discussed are ways that a bituminous subballast can reduce track maintenance needs.

Get full access to this article

View all access options for this article.

References

Selig

E. T.

and Waters

J. M.

Track Geotechnology and Substructure Management. Thomas Telford Publications, London, 1994.

Hunt

G. A.

Use of Advance Computer Models in Permanent Way Life Cycle Cost Reduction. In Proc., 3rd World Congress on Railway Research, Florence, Italy, 1997, Vol. 2, pp. 33–39.

Müller-Boruttau

Ebersbach

and Breisamter

Dynamische Fahrbahnmodelle für HGV-Strecken und Folgerungen für Komponenten. ETR, Eisenbahntechnische Rundschau, Vol. 7–8, November 1998, pp. 696–702.

Sauvage

and Fortin

J. P.

La Trainée de Roulement des Véhicules de Chemin de Fer. Revue Generale des Chemins de Fer, Juiellet-Août, 1982, pp. 383–390.

Teixeira

P. F.

Contribution to the Reduction of Track Maintenance Costs by Optimizing Its Vertical Stiffness. Ph.D. thesis. Technical University of Catalonia, Barcelona, Spain, 2003.

López-Pita

Teixeira

P. F.

and Robusté

High Speed Track Deterioration: The Role of the Vertical Stiffness of the Track. Journal of Rail and Rapid Transit, Vol. 218, No. 1 2004, pp. 31–40.

Rose

J. G.

and Long

Kentrack: A Structural Analysis Program for Heavy Axle Load Railway Trackbed Designs. In Proc., 5th International Conference on Railway Engineering, London, 2003.

Huang

Lin

Deng

and Rose

Kentrack: A Computer Program for Hot-Mix Asphalt and Conventional Ballast Railway Trackbeds. Asphalt Institute, 1984.

Alias

La Voie Ferrée—Techniques de Construction et D'entretien. Editions Eyroles et SNCF, Paris, 1984.

10.

Shenton

M. J.

Ballast Deformation and Track Deterioration. In Track Technology. Thomas Telford Publications, London, 1985.

11.

Ubalde

Track Control and Tamping Works at Madrid-Sevilla High-Speed Line: Analysis of Experience and Deduction of New Criteria for Maintenance. Ph.D. thesis. Technical University of Catalonia, Barcelona, Spain, 2004.

12.

Bergreen

and Jaehlenius

Continuous Track Stiffness Measurement: An Effective Method to Investigate the Structural Conditions of the Track. Proc., Railway Engineering 2002 International Conference, London, 2002.

13.

Thompson

and Kalay

Development of Continuous Lateral and Vertical Track Stiffness Measurement Techniques. Proc., Railway Engineering 2002 International Conference, London, 2002.

14.

Sussmann

and Hyslip

Indications of Railway Track Performance Problems on Embankments from Ground Penetrating Radar. Proc., Railway Engineering 2001 International Conference, London, 2001.

15.

Zaghloul

Ayed

Ahmed

Henderson

Springer

and Vitillo

Effect of Positive Drainage on Flexible Pavement Life-Cycle Cost. In Transportation Research Record: Journal of the Transportation Research Board, No. 1868, Transportation Research Board of the National Academies, Washington, D.C., 2004, pp. 135–141.