Effect of Mercerization on the Tensile Properties of Rotor Spun Yarn

Abstract

Rotor spun 14s cotton yarns were twisted over a range of twist multipliers from 4.25 to 5.5. The yarns were mercerized with sodium hydroxide and stretched to their original length. Tenacity of mercerized yarns was significantly greater than the grey yarns at all twist levels. A substantial improvement of 52.8% in tenacity was observed at the lowest twist. Even slack mercerization improved yarn tenacity at lower twist levels (up to 4.7) close to that for tension mercerized yam. Maximum increase in yarn tenacity by slack mercerization was 46% at the lowest twist. Tension mercerization increases yarn tenacity primarily by improvement of fiber packing at lower twist levels, but at higher twist levels fiber orientation, fiber packing, and improvement in fiber tenacity all affect yarn tenacity.

Get full access to this article

View all access options for this article.

References

Am. Soc. Test. Mat. , "Annual Book of ASTM Standards," part 32, 1977, pp. 349-355.

Barella, A. , and Manich, A. , Mercerization of Cotton and Cotton-Polyester Rotor Yams, Its Effect on Mechanical Characteristics of Yams as a Function of Total Draft and Twist Applied in Spinning, Blended Textile, published by Textile Association India, 250-259, 1981.

Hunter, L. , and Andrews, G. , A Comparison of Open-end and Ring Spinning of Cotton, Part II, the Effects of Caustic Soda and Liquid Ammonia Mercerization on Yam Tensile Properties, SAWTRI Technical Report no. 367, August 1977.

Pillay, K.R.P. , and Nagaraja, B.S. , A Comparative Study of the Response to Mercerization of Open End and Ring Spun Yams," Resume of Papers: 22nd Joint Technological Conference," 1981, pp. 21-24.

Skinkle, J.H. , "Textile Testing," Chemical Publishing Co., Brooklyn, 1972, pp. 268-269.