Hygral Expansion of Woven Wool Fabrics

Abstract

An experimental study is reported of the hygral expansion behavior of a wide range of laboratory produced and some commercially produced wool woven outerwear fabrics. A fabric hygral expansion apparatus simultaneously measures changes in fabric length and fabric moisture regain which occur when the relative humidity of the ambient environment is altered. Fabric and yam hygral expansion curves are analyzed and discussed in terms of the following parameters: hygral expansion coefficient (slope of the initial linear part of the hygral expansion versus moisture regain curve), hygral expansion at 25% regain, and hygral expansion at 30% moisture regain. F bric hygral expansion behavior depends largely on the magnitude of the weave crimp. The effect of weave construction on the fabric hygral expansion is very small at high moisture regains; at low regains, plain-weave fabrics tend to show slightly higher expansion than the corresponding twill structures of similar crimp magnitude. The effect of fiber properties on hygral expansion behavior has been examined for a series of wool plain-weave fabrics produced from yams of the same linear density.

Get full access to this article

View all access options for this article.

References

Baird, K. , Orientation of Merino Wool Fibers in Woven Fabrics, Textile Res. J. 32, 419-421 (1962).

Baird, K. , Changes of Curvature with Regain of Set Wool and Hair Fibers, Textile Res. J. 33, 866-868 (1963).

Baird, K. , Dimensional Stability of Woven Wool Fabrics: Hygral Expansion, Textile Res. J. 33, 973-984 (1963).

Baird, K. , Reaction to Regain Changes of Woven Wool Fabrics: Hygral Expansion, in "Proceedings, 3rd International Wool Textile Research Conference, Paris, (CIRTEL)," vol. IV, 1965, pp. 357-367.

Baird, K. , Hygral Expansion in Wool Fabrics, Wool Sci. Rev., no. 31, 12-31 (1967).

Cednäs, M. , Dimensional Stability of Wool Fabrics, J. Textile Inst. 52, T251-T271 (1961).

Kärrholm, E.M. , and Cednäs, U.M. , and Nordhammar, P.G. , An Experimental Investigation of Relationships between Construction, Finishing and End Properties of Worsted Fabrics, in "Proceedings, 3rd International Wool Textile Research Conference, Paris (CIRTEL)," vol. IV, 1965, pp. 449-461.

Kopke, V. , The Role of Water in the Setting of Wool: A Study of Setting at Temperatures above 100°C, Part II: Fabric Properties, J. Textile Inst. 61, 388-407 ( 1970).

Kopke, V. , Reversible and Irreversible Dimensional Changes in Wool Fabrics , J. Textile Inst. 63, 191-207 ( 1972).

10.

Lindberg, J. , Hygral Expansion of Wool Fabrics, in "Proceedings, 3rd International Wool Textile Research Conference, Paris (CIRTEL)," vol. III, 1965, pp. 53-63.

11.

Olofsson, B. , Setting and Hygral Expansion of Wool Fabrics, Textile Res. J. 32, 1037, 1038 (1962).

12.

Olofsson, B. , The Setting of Wool Fabrics - A Theoretical Study, J. Textile Inst. 52, T272-290 (1961).

13.

Shaw, T. , The Dimensional Stability of Woven Wool Fabrics, Wool Sci. Rev., no. 55, 43-81 (1978).

14.

Shiloh, M. , Hunter, L. , and Smuts, S. , The Effect of Fibre Properties and Weave Crimp on the Hygral Expansion of Woven Wool Fabrics, J. Textile Inst. 73, 238-245 (1982).

15.

Slinger, R.I. , and Smuts, S. , A Study of the Bulk Resistance to Compression of Wool Fibres, SAWTRI Technical Report No. 89, 1967.

16.

Hunter, L. , and Smuts, S. , The Effect of Wool Staple Crimp, Resistance to Compression and Other Fibre Properties on Certain Woven Fabric Properties, SAWTRI Technical Report No. 439, 1979.