A smart insole for monitoring plantar pressure based on the fiber Bragg grating sensing technique

Abstract

The analysis of plantar pressure distribution is essential in the field of biomedical and sports-related applications. In this study, a smart insole was developed for the measurement of plantar pressure distribution and the evaluation of body postures using optical fiber Bragg grating (FBG) sensing technology. Four FBG sensors characterized by four different center Bragg wavelengths, 1528 ± 0.3, 1532 ± 0.3, 1535 ± 0.3 and 1539 ± 0.3 nm, were located at the first metatarsus, third metatarsus, fifth metatarsus and heel position, respectively. The measurement sensitivity of all the FBG sensors was 0.000412 nm/kPa, approximately. Silica gel material of modulus = 10 MPa was selected to incorporate the FBG sensors. All FBG sensors were multiplexed together with one optical fiber cable. The performance and functional properties of all FBG-based pressure sensors were calibrated in the laboratory to evaluate plantar pressure distribution. A male subject was selected for performing four tasks, namely standing in an upright position, leaning forward, squat position and forward fold. During standing tests, plantar pressure observed at the heel position was around 57% higher than that at the first and third metatarsus, while the pressure of the fifth metatarsus position presents minimal pressure, which is only 37% that of the pressure of the heel position. When the subject performs leaning forward, the squat position and forward fold posture, the first and third metatarsi show maximum pressure, while the pressure decreases at the fifth metatarsus position. However, almost zero pressure is observed at the heel position when the subject changes the body postures of leaning forward, squat and forward fold posture. The extreme pressure of the forward fold posture was 1750 kPa acquired at the first metatarsus, which is 52% and 62% higher than those at the fifth and third metatarsi, respectively. Therefore, the smart insole successfully recorded both plantar pressure distribution and body posture changes regarding the wavelength values collected by the FBG sensors.

Keywords

smart insole fiber Bragg grating measurement plantar pressure body posture

Get full access to this article

View all access options for this article.

References

Hung K, Zhang Y-T and Tai B. Wearable medical devices for tele-home healthcare. In: The Proceedings of the 26th Annual International Conference of the IEEE EMBS, San Francisco, CA, USA, 1–5 September 2004, pp. 5384–5387. IEEE.

Yamakawa T, Taniguchi K, Asari K, et al. Biometric personal identification based on gait pattern using both feet pressure change. In: 2008 World Automation Congress (WAC), Hawaii, HI, USA, 28 September–2 October 2008, pp. 1–6. IEEE.

Sazonov

Fulk

Hill

, et al. Monitoring of posture allocations and activities by a shoe-based wearable sensor. IEEE Trans Biomed Eng 2011; 58: 983–990.

Wada C, Sugimura Y, Wada F, et al. Development of a rehabilitation support system with a shoe-type measurement device for walking. In: Proceedings of SICE Annual Conference, Taipei, Taiwan, 18–21 August 2010, pp. 2534–2537. IEEE.

Bonato

. Wearable sensors/systems and their impact on biomedical engineering. IEEE Eng Med Biol Mag 2003; 22: 18–20.

De Rossi S, Lenzi T, Vitiello N, et al. Development of an in-shoe pressure-sensitive device for gait analysis. In: 33rd Annual International Conference of the IEEE EMBS, Boston, Massachusetts USA, 30 August–3 September 2011, pp. 5637–5640. IEEE.

Tao

Liu

Zheng

, et al. Gait analysis using wearable sensors. Sensors 2012; 12: 2255–2283.

Crea

Donati

De Rossi

SMM

, et al. A wireless flexible sensorized insole for gait analysis. Sensors 2014; 14: 1073–1093.

Margolis

Knauss

Bilker

, et al. Medical conditions as risk factors for pressure ulcers in an outpatient setting. Age Ageing 2003; 32: 259–264.

10.

Abdul Razak

Zayegh

Begg

, et al. Foot plantar pressure measurement system: a review. Sensors 2012; 12: 9884–9912.

11.

I-J

Hou

Y-Y

Yang

C-H

, et al. Comparison of plantar pressure distribution between different speed and incline during treadmill jogging. J Sports Sci Med 2010; 9: 154–160.

12.

Sun

, et al. Plantar pressure variation during jogging with different heel height. Appl Bionic Biomech 2013; 10: 89–95.

13.

Lee

Y-C

Lin

Wang

M-JJ

. Evaluating insole design with joint motion, plantar pressure and rating of perceived exertion measures. Work 2012; 41: 1114–1117.

14.

Suresh

Bhalla

Singh

, et al. Combined application of FBG and PZT sensors for plantar pressure monitoring at low and high speed walking. Technol Health Care 2015; 23: 47–61.

15.

Suresh

Singh

Hao

, et al. Fibre Bragg grating sensors for plantar pressure monitoring at different walking speeds. Int J Biomed Eng Technol 2014; 14: 34–45.

16.

Han

J-T

Lee

J-H

Lee

E-J

, et al. Comparison of plantar pressure between flat and normal feet when crossing an obstacle at different heights. J Back Musculoskel Rehab 2015; 28: 629–633.

17.

Shen

. Plantar pressure analysis during tilt walking in female group. Int J Biomed Eng Technol 2013; 11: 357–363.

18.

Kellis

. Plantar pressure distribution during barefoot standing, walking and landing in preschool boys. Gait Posture 2001; 14: 92–97.

19.

Periyasamy

Anand

. The effect of foot arch on plantar pressure distribution during standing. J Med Eng Technol 2013; 37: 342–347.

20.

Hills

Hennig

McDonald

, et al. Plantar pressure differences between obese and non-obese adults: a biomechanical analysis. Int J Obesity 2001; 25: 1674–1674.

21.

Chen M, Huang B and Xu Y. Intelligent shoes for abnormal gait detection. In: IEEE International Conference on Robotics and Automation, (ICRA 2008), Pasadena, CA, USA, 19–23 May 2008, pp. 2019–2024. IEEE.

22.

Liang

T-C

Lin

J-J

Guo

L-Y

. Plantar pressure detection with fiber Bragg gratings sensing system. Sensors 2016; 16: 1766–1766.

23.

Zhang

Y-F

Hong

C-Y

Ahmed

, et al. A fiber Bragg grating based sensing platform fabricated by fused deposition modeling process for plantar pressure measurement. Measurement 2017; 112: 74–79.

24.

Domingues

Tavares

Leitão

, et al. Insole optical fiber Bragg grating sensors network for dynamic vertical force monitoring. J Biomed Optic 2017; 22: 091507–091507.

25.

Tavares

Domingues

Frizera-Neto

, et al. Gait shear and plantar pressure monitoring: a non-invasive OFS based solution for e-health architectures. Sensors 2018; 18: 1334–1354.

26.

Kersey

Davis

Patrick

, et al. Fiber grating sensors. J Lightwave Technol 1997; 15: 1442–1463.

27.

Abro

Zhang

Y-F

Hong

C-Y

, et al. Development of a smart garment for monitoring body postures based on FBG and flex sensing technologies. Sensor Actuator A Phys 2018; 272: 153–160.

28.

Hong

C-Y

Zhang

Y-F

Zhang

M-X

, et al. Application of FBG sensors for geotechnical health monitoring, a review of sensor design, implementation methods and packaging techniques. Sensor Actuator A Phys 2016; 244: 184–197.

29.

Chan

Tam

H-Y

, et al. Fiber Bragg grating sensors for structural health monitoring of Tsing Ma bridge: background and experimental observation. Eng Struct 2006; 28: 648–659.

30.

Rao

Y-J

Webb

Jackson

, et al. In-fiber Bragg-grating temperature sensor system for medical applications. J Lightwave Technol 1997; 15: 779–785.

31.

Dziuda

Skibniewski

Krej

, et al. Monitoring respiration and cardiac activity using fiber Bragg grating-based sensor. IEEE Trans Biomed Eng 2012; 59: 1934–1942.

32.

Mishra

Singh

Tiwari

, et al. Fiber grating sensors in medicine: current and emerging applications. Sensor Actuator A Phys 2011; 167: 279–290.

33.

Gagliardi

Salza

Ferraro

, et al. Design and test of a laser-based optical-fiber Bragg-grating accelerometer for seismic applications. Meas Sci Technol 2008; 19: 085306–085306.

34.

Fernandez

Gusarov

Bodart

, et al. Temperature monitoring of nuclear reactor cores with multiplexed fiber Bragg grating sensors. Opt Eng 2002; 41: 1246–1254.

35.

Buric

Chen

Maklad

, et al. Multiplexable low-temperature fiber Bragg grating hydrogen sensors. IEEE Photon Technol Lett 2009; 21: 1594–1596.

36.

Shu

Hua

Wang

, et al. In-shoe plantar pressure measurement and analysis system based on fabric pressure sensing array. IEEE Trans Inform Technol Biomed 2010; 14: 767–775.