The thermal protective performance of fabrics against hot liquid splashes was investigated under different configurations. The air gap of 6 mm between specimen and sensor was simulated and compared with direct contact configuration. Three liquids (distilled water, canola oil, drilling mud) at 85℃ were applied as challenge hot liquid hazards. The results showed that fabric permeability significantly affected heat transfer due to the occurrence of mass transfer both with and without a spacer. The absorbed energy and second-degree burn time presented significantly negative correlation. The effect of air gap on thermal performance was investigated. The findings demonstrated that minimizing mass transfer could effectively improve thermal protection against hot liquid splashes and the existing of an air layer could improve thermal performance.
BarrDGregsonWReillyT. The thermal ergonomics of firefighting reviewed. Appl Erg2010; 41: 161–172.
2.
BarkerRLYenerM. Evaluating the resistance of some protective fabrics to molten iron. Textil Res J1981; 51: 533–541.
3.
MäkinenHNieminenKMäkiS. Development of a test method against hot alkaline chemical splashes. Int J Occup Safety Erg2008; 14: 19–28.
4.
RossiRIndelicatoEBolliW. Hot steam transfer through heat protective clothing layers. Int J Occup Safety Erg2004; 10: 239–245.
5.
SatiRCrownEMAckermanM. Protection from steam at high pressures: development of a test device and protocol. Int J Occup Safety Erg2008; 14: 29–41.
6.
TaylorAJMcGwinGCrossJM. Serious occupational burn injuries treated at a regional burn center. J Burn Care Rehabil2002; 23: 244–248.
7.
SmithGSWellmanHMSorockGS. Injuries at work in the US adult population: contributions to the total injury burden. Am J Public Health2005; 95: 1213–1219.
8.
WilkinsKMackenzieSG. Work injuries. Health Rep2007; 18: 25–42.
9.
LeeYMBarkerRL. Thermal protective performance of heat-resistant fabrics in various high intensity heat exposures. Textil Res J1987; 57: 123–132.
10.
TorviDADaleJD. Effects of variations in thermal properties on the performance of flame resistant fabrics for flash fires. Textil Res J1998; 68: 787–796.
11.
SunGYooHSZhangXS. Radiant protective and transport properties of fabrics used by wildland firefighters. Textil Res J2000; 70: 567–573.
12.
TanYBCrownEMCapjackL. Design and evaluation of thermal protective flight-suits. Part I: the design process and prototype development. Cloth Textil Res J1998; 16: 47–55.
13.
TorviDAHadjisophocleousGV. Research in protective clothing for firefighters: state of the art and future directions. Fire Technol1999; 35: 111–130.
14.
KimIYLeeCLiP. Investigation of air gaps entrapped in protective clothing systems. Fire Mater2002; 26: 121–126.
15.
SongG. Clothing air gap layers and thermal protective performance in single layer garment. J Ind Textil2007; 36: 193–205.
16.
MahTSongGW. Investigation of the contribution of garment design to thermal protection. Part 1: characterizing air gaps using three-dimensional body scanning for women's protective clothing. Textil Res J2010; 80: 1317–1329.
17.
SongGW. Modeling thermal protection outfits for fire exposures, Raleigh, NC: North Carolina State University, 2002, pp. 1–224.
18.
TorviDADaleJDFaulknerB. Influence of air gaps on bench-top test results of flame resistant fabrics. J Fire Prot Eng1999; 10: 1–12.
19.
SawcynCMJTorviDA. Improving heat transfer models of air gaps in bench top tests of thermal protective fabrics. Textil Res J2009; 79: 632–644.
20.
MahTSongGW. Investigation of the contribution of garment design to thermal protection. Part 2: instrumented female mannequin flash-fire evaluation system. Textil Res J2010; 80: 1473–1487.
21.
WangYYLuYHLiJ. Effects of air gap entrapped in multilayer fabrics and moisture on thermal protective performance. Fiber Polym2012; 13: 647–652.
22.
LiJLuYHLiXH. Effect of relative humidity coupled with air gap on heat transfer of flame-resistant fabrics exposed to flash fire. Textil Res J2012; 83: 1235–1243.
23.
LuYHLiJLiXH. The effect of air gaps in moist protective clothing on protection from heat and flame. J Fire Sci, Epub ahead of print 2012, September 12. DOI: 10.1177/0734904112457342.
24.
HesLAraujo deM. Simulation of the effect of air gaps between the skin and a wet fabric on resulting cooling flow. Textil Res J2010; 80: 1488–1497.
25.
Jalbani SH, Ackerman MY, Crown EM, et al. Modification of ASTM F 2701-08 apparatus for use in evaluating protection from low pressure hot water jets. In: 9th symposium on performance of protective clothing and equipment: emerging issues and technologies, Anaheim, CA: ASTM Committee F23 on Personal Protective Clothing and Equipment, 2011.
26.
Ackerman MY, Song GW, Gholamreza F, et al. Analyzing thermal protective clothing performance against the impact of small splashes of hot liquid. In: 9th symposium on performance of protective clothing and equipment: emerging issues and technologies, Anaheim, CA: ASTM Committee F23 on Personal Protective Clothing and Equipment, 2011.
27.
NealT. Hot liquid results on NASCO materials. ASTM Work Item WK6682, Guilford, CT: Neal Associates Ltd, 2006.
28.
Lu YH, Song GW, Li J, et al. Analyzing impact penetration performance of fabrics used in protective clothing. In: fiber society spring conference, St. Gallen, Switzerland, 2012.
29.
PrzybylskiRMagTEskinNAMCanola oil. In: ShahidiF (eds). Bailey's industrial oil and fat products2005, 6th edn., New York: John Wiley & Sons, Inc..
30.
FasinaOOColleyZ. Viscosity and specific heat of vegetable oils as a function of temperature: 35℃ to 180℃. Int J Food Prop2008; 11: 738–746.
American Society for Testing and Materials. ASTM F2701-08 Standard Test Method for Evaluating Heat Transfer through Materials for Protective Clothing Upon Contact with a Hot Liquid Splash. American Society for Testing and Materials, West Conshohocken, PA, 2008.
33.
American Society for Testing and Materials. ASTM D1777-96 Standard Test Method for Thickness of Textile Materials. American Society for Testing and Materials, West Conshohocken, PA, 1996.
34.
American Society for Testing and Materials. ASTM D737-04 Standard Test Method for Air Permeability of Textile Fabrics. American Society for Testing and Materials, West Conshohocken, PA, 2004.
35.
TorviDA. Heat transfer in thin fibrous materials under high heat flux conditions, Edmonton: University of Alberta, 1997, pp. 268–271.
36.
PennesHH. Analysis of tissue and arterial blood temperatures in the resting human forearm. J Appl Physiol1948; 1: 93–122.
37.
HenriquesFCMoritzAR. Studies of thermal injury: I. The conduction of heat to and through skin and the temperature attained therein. Am J Pathol1947; 23: 531–549.
38.
CamenzindMADaleJDRossiRM. Manikin test for flame engulfment evaluation of protective clothing: historical review and development of a new ISO standard. Fire Mater2007; 31: 285–295.
