High-resolution and Analytical Electron Microscopic Studies of New Crystals Induced by a Bioactive Ceramic (Diopside)

Abstract

Diopside has been developed for use in dental root implants and for the filling of bone defects. In previous studies, diopside developed hydroxyapatite (HA) on its surface and achieved a direct bond with bone. The purpose of this study was to investigate the mechanism of crystal formation on the diopside surface. We ultrastructurally evaluated the interface between new diopside-induced crystals and diopside. Specimens were prepared in three experiments: (1) Granular diopside was immersed in simulated body fluid (SBF); (2) granular diopside was implanted into a cavity in rabbit bone; and (3) a diopside dental root implant was implanted into a Japanese monkey. The specimens were examined by contact microradiography, high-resolution transmission electron microscopy, and analytical electron microscopy. In the experiment with SBF, many platelet-like crystals formed in the diopside surface layer. The lattice of diopside and that of the new crystals were very close, but no clear continuation of the lattice was observed. In the experiments which used a rabbit and a monkey, contact microradiography showed close contact between bone and diopside. High-resolution transmission electron microscopy revealed crystal growth from the diopside surface layer, and continuity between the diopside lattice and that of the new crystals. The morphological characteristics of the new crystals and the results of these analyses suggest that these new crystals are HA. With regard to the mechanism by which crystals are formed on the diopside surface layer, it is possible that epitaxial crystal growth could originate as a nucleus on the surface. In this case, epitaxial crystal growth of primarily octacalcium phosphate (OCP) may have occurred, and this may have changed to HA by a phase transition. However, epitaxial growth of OCP on the diopside surface is still highly speculative, since there is no direct supporting evidence.

Keywords

bioactive ceramic crystal growth diopside epitaxy high-resolution TEM

Get full access to this article

View all access options for this article.

References

Berry LG , editor (1974). 11-654 DIOPSIDE. 9-432 HYDROXYL-APATITE. In: Selected powder diffraction data for minerals. Published by the Joint Committee on Powder Diffraction Standards.

Brown WE (1966). Crystal growth of bone mineral. Clin Orthop 44:205-220.

Cheng PT (1985). Octacalcium phosphate formation in vitro: implications for bone formation. Calcif Tissue Int 37:91-94. Dallemagne MJ , Richelle LJ (1973). Inorganic chemistry of bone. In: Biological mineralization. Zipkin I, editor. New York: Wiley-Interscience Publication , pp. 23-42.

Dickens B. , Schroeder LW , Brown WE (1974). Crystallographic studies of the role of Mg as a stabilizing impurity in β-Ca3(PO4)2. I. The crystal structure of pure β-Ca3(PO4)2 . J Solid State Chem 10:232-248.

Eanes ED , Gillessen IH , Posner AS (1965). Intermediate states in the precipitation of hydroxyapatite . Nature 208:365-367. Kokubo T. (1990). Surface chemistry of bioactive glass-ceramics. J Non-Crystalline Solids 120:138-151.

Kokubo T. (1993). Bioactivity of glasses and glass ceramics. In: Bone-bonding biomaterials. Ducheyne P , Kokubo T , Van Blitterswijk CA , editors. Leiderdort: Reed Healthcare Communications, pp. 31-46.

Kuboki Y. (1989). Mechanisms of hard tissue formation. In: Principles of hard tissue reconstruction. Sapporo: Fuji-Xerox Inc., pp. 31-166.

Kuboki Y. , Fujisawa R. (1990). Mineralization. In: Bioscience and biotechnology of extracellular matrix. Fujimoto D , editor. Tokyo: IPC Press, pp. 220-238.

Levine RS (1972). Remineralization of human carious dentine in vitro . Arch Oral Biol 17:1005-1008.

10.

Li P. , Ohtuki C. , Kokubo T. , Nakanishi K. , Soga N. , Nakamura T. , et al. (1992). Apatite formation induced by silica gel in a simulated body fluid. J Am Ceram Soc 75:2094-2097.

11.

Meyer JL , Eanes ED (1978). A thermodynamic analysis of the amorphous to crystalline calcium phosphate transformation. Calcif Tissue Res 25:59-68.

12.

Miake Y. , Shimoda S. , Fukae M. , Aoba T. ( 1993). Epitaxial overgrowth of apatite crystals on the thin-ribbon precursor at early stages of porcine enamel mineralization. Calcif Tissue Res 53:249-256.

13.

Moriwaki Y. (1981). Crystallography of tooth mineral. In: Tooth. Suga S , editor. Tokyo: Kyoritu Press, pp. 72-91.

14.

Nakajima S. (1990). Experimental studies of healing process on reinforcement ceramic implantation in rabbit mandible. Shikwa Gakuho 90:525-553.

15.

Nakajima S. , Harada Y. , Kurihara Y. , Wakatsuki T. , Noma H.

16.

Nelson DGA , McLean JD (1984). High-resolution electron microscopy of octacalcium phosphate and its hydrolysis products. Calcif Tissue Int 36:219-232.

17.

Neo M. , Kotani S. , Nakamura T. , Yamamuro T. , Ohtsuki C. , Kokubo T. , et al. (1992). A comparative study of ultrastructures of the interfaces between four kinds of surface-active ceramic and bone. J Biomed Mater Res 26:1419-1432.

18.

Neuman WF , Neuman MW (1958). The mineral phase. In: The chemical dynamics of bone mineral. Chicago: The University of Chicago Press, pp. 39-54.

19.

Newesely H. (1976). Formation and transformation of the poorly soluble calcium phosphates in healthy and carious hard dental tissues. In: Mechanisms and action of trace elements in the mineralization of dental hard tissues. Nyon, Switzerland: Zyma SA, pp. 33-68.

20.

Nonami T. (1992). Developmental study of diopside for use as implant material. In: Tissue-inducing biomaterials. Linda GC , Eyal SR , editors. Materials Research Society Symposium Proceedings. Vol. 252. Pittsburgh, PA: Materials Research Society, pp. 87-92.

21.

Okazaki M. (1992). Crystal structures. In: Chemistry of apatites. Tokyo: Tokai University Press, pp. 1-26.

22.

Royer L. (1928). Recherches experimentales sur 1'epitaxie ou orientation mutuelle de cristaux d'especes differentes. Bull Soc Franc Min 51:7-154.

23.

Takagi T. , Sasaki S. , Aoki H. , Kikuchi M. (1993). Crystal chemistry of secretory stage in developing enamel. Jpn J Oral Biol 35:338-348.

24.

Takuma S. , Tohda H. , Watanabe K. , Yama S. ( 1986). Size increase of dentin crystals in the intertubular matrix due to caries. J Electron Microsc 35:60-65.

25.

Termine JD , Posner AS (1967). Amorphous/crystalline interrelationships in bone mineral. Calcif Tissue Res 1:8-23.