The aim of this study was to evaluate relationships between the revised NIOSH lifting equation (RNLE) and risk of low-back pain (LBP).
Background:
The RNLE is commonly used to quantify job physical stressors to the low back from lifting and/or lowering of loads. There is no prospective study on the relationship between RNLE and LBP that includes accounting for relevant covariates.
Method:
A cohort of 258 incident-eligible workers from 30 diverse facilities was followed for up to 4.5 years. Job physical exposures were individually measured. Worker demographics, medical history, psychosocial factors, hobbies, and current LBP were obtained at baseline. The cohort was followed monthly to ascertain development of LBP and quarterly to determine changes in job physical exposure. The relationship between LBP and peak lifting index (PLI) and peak composite lifting index (PCLI) were tested in multivariate models using proportional hazards regression.
Results:
Point and lifetime prevalences of LBP at baseline were 7.1% and 75.1%, respectively. During follow-up, there were 123 incident LBP cases. Factors predicting development of LBP included job physical exposure (PLI and PCLI), history of LBP, psychosocial factors, and housework. In adjusted models, risk (hazard ratio [HR]) increased per-unit increase in PLI and PCLI (p = .05 and .02; maximum HR = 4.3 and 4.2, respectively). PLI suggested a continuous increase in risk with an increase in PLI, whereas the PCLI showed elevated, but somewhat reduced, risk at higher exposures.
Conclusion:
Job physical stressors are associated with increased risk of LBP. Data suggest that the PLI and PCLI are useful metrics for estimating exposure to job physical stressors.
BakkerE. W. P.VerhagenA. P.van TrijffelE.LucasC.KoesB. W. (2009). Spinal mechanical load as a risk factor for low back pain: A systematic review of prospective cohort studies. Spine, 34, 281–293.
2.
BaloghI.OrbaekP.OhlssonK.NodanderC.UngeJ.WinkelJ.HanssonG. (2004). Self-assessed and directly measured occupational physical activities-influence of musculoskeletal complaints, age and gender. Applied Ergonomics, 35, 49–56.
3.
BigosS. J.BattiéM. C.SpenglerD. M.FisherL. D.FordyceW. E.HanssonT. H.NachemsonA. L.WortleyM. D. (1991). A prospective study of work perceptions and psychosocial factors affecting the report of back injury. Spine, 16, 1–6.
4.
BigosS.BowyerO.BraenG. (1994). Acute low back problems in adults. Clinical Practice Guidelines No. 14 (AHCRP Publication No. 95-0642). Rockville, MD: Agency for Health Care Policy and Research, Public Health Service, U.S. Department of Health and Human Services.
5.
BodaS.GargA.Campbell-KyureghyanN. (2012). Can the revised NIOSH lifting equation predict low back pain incidence in a “90-day-pain-free-cohort”? In Proceedings of the Human Factors and Ergonomics Society 56th Annual Meeting (pp. 1178–1182). Santa Monica, CA: Human Factors and Ergonomics Society.
6.
BongersP. M.De WinterC.KompierM. A. J.HildebrandtV. H. (1993). Psychosocial factors at work and musculoskeletal disease. Scandinavian Journal of Work, Environment, and Health, 19, 297–312.
7.
BurdorfA. (2010). The role of assessment of biomechanical exposure at the workplace in the prevention of musculoskeletal disorders. Scandinavian Journal of Work, Environment, and Health, 36, 1–2.
8.
Bureau of Labor Statistics. (2011). Nonfatal occupational injuries and illnesses requiring days away from work, 2010 (USDL-11-1612). Washington, DC: Author. Retrieved from http://www.bls.gov/iif/oshcdnew.htm
9.
ChaffinD. B.ParkK. S. (1973). A longitudinal study of low back pain as associated with occupational lifting factors. American Industrial Hygiene Association Journal, 34, 513–525.
10.
ClaysE.De BacquerD.LeynenF.KornitzerM.KittelF.De BackerG. (2007). The impact of psychosocial factors on low back pain: Longitudinal results from the Belstress study. Spine, 32, 262–268.
CollettD. (2003). Modeling survival data in medical research. London, UK: Chapman & Hall/CRC.
13.
CoxD. R. (1972). Regression models and life tables. Journal of the Royal Statistical Society: Series B, 34, 187–220.
14.
DavisK. G.HeaneyC. A. (2000). The relationship between psychosocial work characteristics and low back pain: Underlying methodological issues. Clinical Biomechanics, 15, 389–406.
15.
de VetH. C. W.HeymansM. W.DunnK. M.PopeD. P.van der BeekA. J.MacfarlaneG. J.BouterL. M.CroftP. R. (2002). Episodes of low back pain: A proposal for uniform definitions to be used in research. Spine, 27, 2409–2416.
16.
DeyoR.Tsui-WuY. (1987). Descriptive epidemiology of low-back pain and its related medical care in the United States. Spine, 12, 264–268.
17.
DunningK. K.DavisK. G.CookC.KotowskiS. E.HamrickC.JewellG.LockeyJ. (2010). Costs by industry and diagnosis among musculoskeletal claims in a state workers compensation system: 1999–2004. American Journal of Industrial Medicine, 53, 276–284.
18.
GargA.ChaffinD. B. (1975). A biomechanical computerized simulation of human strength. AIIE Transactions, 7, 1–15.
19.
GargA.KapelluschJ. M. (2009a). Applications of biomechanics for prevention of work-related musculoskeletal disorders. Ergonomics, 52, 36–59.
20.
GargA.KapelluschJ. (2009b, August). Consortium pooled data job physical exposure assessment. Paper presented at the 17th International Ergonomics Association World Conference, Beijing, China.
21.
GargA.KapelluschJ.HegmannK.WertschJ.MerryweatherA.Deckow-SchaeferG.MalloyE., & WISTAH Hand Study Research Team. (2012). The strain index (SI) and threshold limit value (TLV) for hand activity level (HAL): Risk of carpal tunnel syndrome (CTS) in a prospective cohort. Ergonomics, 55, 396–414.
22.
HarknessE. F.McfarlaneG. J.NahitE. S.SilmanA. J.McbethJ. (2003). Risk factors for new-onset low back pain amongst cohorts of newly employed workers. Rheumatology, 42, 959–968.
23.
HartvigsenJ.BakketeigL. S.Leboeuf-YdeC.EngbergM.LauritzenT. (2001). The association between physical workload and low back pain clouded by the “healthy worker” effect: Population-based cross-sectional and 5-year prospective questionnaire study. Spine, 26, 1788.
24.
HartvigsenJ.LingsS.deLeboeuf-YBakketeigL. (2004). Psychosocial factors at work in relation to low back pain and consequences of low back pain: A systematic, critical review of prospective cohort studies. Occupational and Environmental Medicine, 61, e2.
25.
HaydenJ. A.ChouR.Hogg-JohnsonS.BombardierC. (2009). Systematic reviews of low back pain prognosis had variable methods and results: Guidance for future prognosis reviews. Journal of Clinical Epidemiology, 62, 781–796.
26.
HeneweerH.VanheesL.PicavetH. (2009). Physical activity and low back pain: A U-shaped relationship?Pain, 143, 21–25.
27.
HerrinG. D.JaraiediM.AndersonC. K. (1986). Prediction of over-exertion injuries using biomechanical and psychophysical models. American Industrial Hygiene Association Journal, 47, 322–330.
28.
HincapieC. A.CassidyJ. D.CoteP. (2008). Is history of work-related low back injury associated with prevalent low back pain and depression in general population? BMC Musculoskeletal Disorders, 9, 22.
29.
HoogendoornW. E.BongersP. M.de VetH. C. W.AriensG. A.van MechelenW.BouterL. M. (2002). High physical work load and low job satisfaction increase the risk of sickness absence due to low back pain: Results of a prospective cohort study. Occupational and Environmental Medicine, 59, 223–328.
30.
HoogendoornW. E.BongersP. M.de VetH. C. W.DouwesM.KoesB. W.MiedemaM. C.AriensG. A.BouterL. M. (2000). Flexion and rotation of the trunk and lifting at work are risk factors for low back pain: Results of a prospective cohort study. Spine, 25, 3087–3092.
31.
HoogendoornW. E.BongersP. M.de VetH. C. W.TwiskJ. W. R.van MechelenW.BouterL. M. (2002). Comparison of two different approaches for the analysis of data from a prospective cohort study: An application to work related risk factors for low back pain. Occupational and Environmental Medicine, 59, 459–465.
32.
HoogendoornW. E.van PopelM. N.BongersP. M.KoesB. W.BouterL. M. (1999). Physical load during work and leisure time as risk factors for back pain. Scandinavian Journal of Work, Environment, and Health, 25, 387–403.
33.
HoogendoornW. E.van PopelM. N.BongersP. M.KoesB. W.BouterL. M. (2000). Systematic review of psychosocial factors at work and private life as risk factors for back pain. Spine, 25, 2114–2125.
34.
HurvichC. M.TsaiC.-L. (1989). Regression and time series model selection in small samples. Biometrika, 76, 297–307.
35.
JansenJ. P.BurdorfA. (2003). Effects of measurement strategy and statistical analysis on dose-response relations between physical workload and low back pain. Occupational and Environmental Medicine, 60, 942–947.
36.
JansenJ. P.MorgensternH.BurdorfA. (2004). Dose-response relations between occupational exposure and psychosocial factors and the risk of low back pain. Occupational and Environmental Medicine, 61, 972–979.
37.
KuceraK. L.LoomisD.LipscombH. J.MarshallS. W.MirkaG.DanielsJ. (2009). Ergonomic risk factors for low back pain in North Carolina crab pot and gill net commercial fishermen. American Journal of Industrial Medicine, 52, 311–321.
38.
Leboeuf-YdeC. (2000). Body weight and low back pain: A systematic literature review of 56 journal articles reporting on 65 epidemiologic studies. Spine, 25, 226–337.
39.
LilesD. H.MahajanP. (1985). Using NIOSH lifting guide decreases risk of back injury. Occupational Health and Safety, 54, 57–60.
40.
LinD. Y.WeiL. J.YingZ. (1993). Checking the Cox model with cumulative sums of Martingale-based residuals. Biometrika, 80, 557–572.
41.
MacfarlaneG. J.PallewateN.PaudyalP.BlythF. M.CoggonD.GrombzG.LintonS.Leino-ArjasP.SilmanA. J.SmeetsR. J.van der WindtD. (2009). Evaluation of work-related psychosocial factors and regional musculoskeletal pain: Results from a EULAR task force. Annals of the Rheumatic Diseases, 66, 885–891.
42.
ManchikantiL. (2000). Epidemiology of low back pain. Pain Physician, 3, 167–192.
43.
MarrasW. S.DavisK. G.HeaneyC. A.MaronitisA.AllreadW. G. (2000). The influence of psychosocial stress, gender, and personality on mechanical loading of the lumbar spine. Spine, 25, 3045–3054.
44.
MarrasW. S.FineL. J.FergusonS. A.WatersT. R. (1999). The effectiveness of commonly used lifting assessment methods to identify industrial jobs associated with elevated risk of low-back disorders. Ergonomics, 42, 229–245.
45.
MarrasW. S.LavenderS. A.FergusonS. A.SplittstoesserR. E.YangG. (2010). Quantitative dynamic measures of physical exposure predict low back functional impairment. Spine, 35, 914–923.
46.
MarrasW. S.LavenderS. A.LeurgansS. E.RajuluS. L.AllreadW. G.FathallahF. A.FergusonS. A. (1993). The role of dynamic three-dimensional trunk motion in occupationally related low back disorders. Spine, 18, 617–628.
47.
MatsudairaK.KonishiH.MiyoshiK.IsomuraT.TakeshitaK.HaraN.YamadaK.MachidaH. (2012). Potential risk factors for new onset of back pain disability in Japanese workers: Findings from the Japan epidemiological research of occupation-related back pain study. Spine, 37, 1324–1333.
48.
MirkaG. A.KelaherD. P.NayD. T.LawrenceB. M. (2000). Continuous assessment of back stress (CABS): A new method to quantify low-back stress in jobs with variable biomechanical demands. Human Factors, 42, 209–225.
49.
NelsonN. A.HughesR. E. (2009). Quantifying relationships between selected work-related risk factors and back pain: A systematic review of objective biomechanical measures and cost-related health outcomes. International Journal of Industrial Ergonomics, 39, 202–210.
50.
NormanR.WellsR.NeumannP.FrankJ.ShannonH.KerrM. (1998). A comparison of peak vs. cumulative physical work exposure risk factors for the reporting of low back pain in the automotive industry. Clinical Biomechanics (Bristol, Avon), 13, 561–573.
51.
OzgulerA.LeclercA.LandreM.Pietri-TalebF.NiedhammerI. (2000). Individual and occupational determinants of low back pain according to various definitions of low back pain. Journal of Epidemiology and Community Health, 54, 215–220.
52.
PapageorgiouA.CroftP.FerryS.JaysonM.SilmanA. (1995). Estimating the prevalence of low back pain in the general population: Evidence from the South Manchester Back Pain Survey. Spine, 20, 1889–1894.
53.
PapageorgiouA. CMacfarlaneG. J.ThomasE.CroftP. R.JaysonM. I.SilmanA. J. (1997). Psychosocial factors in the workplace: Do they predict new episodes of low back pain? Evidence from the South Manchester Back Pain Study. Spine, 22, 1137–1142.
54.
PlouvierS.LeclercA.ChastangJBonenfantS.GoldbergM. (2009). Socioeconomic position and low-back pain: The role of biomechanical strains and psychosocial work factors in the GAZEL cohort. Scandinavian Journal of Work, Environment, and Health, 35, 429–436.
55.
PunnetL.WegmanD. H. (2004). Work-related musculoskeletal disorders: The epidemiologic evidence and the debate. Journal of Electromyography and Kinesiology, 14, 13–23.
56.
R Development Core Team. (2011). R: A language and environment for statistical computing. Vienna, Austria: R Foundation for Statistical Computing. Retrieved from http://www.R-project.org/
57.
RamondA.BoutonC.RichardI.RoquelaureY.BaufretonC.LegrandE.HuezJ. (2011). Psychosocial risk factors for chronic low back pain in primary care: A systematic review. Family Practice, 28, 12–21.
58.
RiihimakiH. (2000). Epidemiology of work-related back disorders. In ViolanreF.ArmstrongT.KilbomA. (Eds.), Occupational ergonomics: Work related musculoskeletal disorders of the upper limb and back (pp. 11–19). New York, NY: Taylor & Francis.
59.
RuppertD.WandM. P.CarrollR. J. (2003). Semiparametric regression. Cambridge, UK: Cambridge University Press.
60.
RussellS. J.WinnemullerL.CampJ. E.JohnsonP. W. (2007). Comparing the results of five lifting analysis tools. Applied Ergonomics, 38, 91–97.
61.
ShiriR.KarppinenJ.Leini-ArhasP.SolovievaS.Viikari-JunturaE. (2009). The association between obesity and low back pain: A meta-analysis. American Journal of Epidemiology, 171, 135–154.
62.
SpielholzP.SilversteinB.MorganM.CheckowayH.KaufmanJ. (2001). Comparison of self-report, video observation and direct measurement methods for upper extremity musculoskeletal disorder physical risk factors. Ergonomics, 44, 588–613.
63.
TakalaE. P.PehkonenI.ForsmanM.HanssonG. A.MathiassenS. E.NeumannW. P.SjogaardG.VeierstedK. B.WestgaardR. H.WinkelJ. (2010). Systematic evaluation of observational methods assessing biomechanical exposures at work. Scandinavian Journal of Work, Environment, and Health, 36, 3–24.
64.
TherneauT. M.GrambschP. M.FlemingT. R. (1990). Martingale-based residuals for survival models. Biometrika, 77, 147–160.
65.
TubachF.LeclercA.LandreM.Pietri-TalebF. (2002). Risk factors for sick leave due to low back pain: A prospective study. Journal of Occupational and Environmental Medicine, 44, 451–458.
66.
van der BeekA. J.MathiassenS. E.WindhorstJ.BurdorfA. (2005). An evaluation of methods assessing the physical demands of manual lifting in scaffolding. Applied Ergonomics, 36, 213–222.
67.
Van NieuwenhuyseA.FathutdinovaL.VerbekeG.PirenneD.JohannikK.SomvilleP. R.MairiauxPh.MoensG. F.MasscheleinR. (2004). Risk factors for first-ever low back pain among workers in their first employment. Occupational Medicine, 54, 513–519.
68.
Van NieuwenhuyseA.SomvilleP.R.CrombezG.BurdorfA.VerbekeG.JohannikK.van den BerghO.MasscheleinR.MairiauxP.MoensG. F., & BelCoBack Study Group. (2006). The role of physical workload and pain related fear in the development of low back pain in young workers: Evidence from the BelCoBack Study. Results after one year of follow up. Occupational and Environmental Medicine, 63, 45–52.
69.
VandergriftJ. L.GoldJ. E.HanlonA.PunnettL. (2012). Physical and psychosocial ergonomic risk factors for low back pain in automobile manufacturing workers. Occupational and Environmental Medicine, 69, 29–34.
70.
WalkerB. F.MullerR.GrantW. D. (2004). Low back pain in Australian adults: Prevalence and associated disability. Journal of Manipulative & Physiological Therapeutics, 27, 238–244.
WatersT. R.BaronS. L.PiacitelliL. A.AndersonV. P.SkovT.Haring-SweeneyM.WallD. K.FineL. J. (1999). Evaluation of the revised NIOSH lifting equation: A cross-sectional epidemiologic study. Spine, 24, 386–395.
73.
WatersT. R.LuM.PiacitelliL. A.WerrenD.DeddensJ. A. (2011). Efficacy of the revised NIOSH lifting equation to predict low back pain due to manual lifting: Expanded cross-sectional analysis. Journal of Occupational and Environmental Medicine, 53, 1061–1067.
74.
WatersT. R.Putz-AndersonV.BaronS. (1998). Methods for assessing physical demands of manual lifting: A review and case study from warehousing. American Industrial Hygiene Association Journal, 59, 871–881.
75.
WatersT. R.Putz-AndersonV.GargA.FineL. J. (1993). Revised NIOSH equation for the design and evaluation of manual lifting tasks. Ergonomics, 36, 749–776.
76.
WatersT. R.Putz-AndersonV.GargA.FineL. J. (1994). Applications manual for the revised NIOSH lifting equation (Pub. No. 94-110). Cincinnati, OH: U.S. Department of Health and Human Services, National Institute for Occupational Safety and Health.
77.
World Health Organization. (2003). The burden of musculoskeletal conditions at the start of the new millennium. World Health Organ Tech Report, 919, 1–218.
78.
ZungW. W. (1965). A self-rating depression scale. Archives of General Psychiatry, 12, 63–70.
