The recrystallization behaviour during annealing of cold-rolled Cu–5Fe–2Sn alloy was clarified in this paper. The effects of annealing temperature and time on the microstructure and properties of the Cu–5Fe–2Sn alloy were investigated. The equations of electrical conductivity and recrystallization kinetics during annealing were obtained with Martition's rule and Avrami empirical formula. The variations of recrystallization volume fraction and the growth of recrystallization grain for Cu–5Fe–2Sn alloy after 40% cold rolling were discussed. The calculated conductivity and volume fraction of recrystallization have a good match with experimental results. The variations of the properties of annealed Cu–5Fe–2Sn alloy are attributed to the growth rate of recrystallization phase and the size of recrystallization grains.
WuZWChenYMengL.Effects of rare earth elements on annealing characteristics of Cu–6 wt-% Fe composites. J Alloy Compd. 2009; 477:198–204. doi: 10.1016/j.jallcom.2008.10.047
2.
PangYXiaCDWangMPEffects of Zr and (Ni, Si) additions on properties and microstructure of Cu–Cr alloy. J Alloy Compd. 2014; 582:786–792. doi: 10.1016/j.jallcom.2013.08.146
3.
SharmaGChongCSEbinLPatterned micropads made of copper nanowires on silicon substrate for application as chip to substrate interconnects. Nanotech. 2007; 18:305–306.
4.
JahaziMHossein-NejadS.The development of an optimum manufacturing and material selection process for the fabrication of labyrinth seal strips. J Mater Process Tech. 2004; 152:272–275. doi: 10.1016/j.jmatprotec.2003.11.035
5.
ChbihiASauvageXBlavetteD.Atomic scale investigation of Cr precipitation in copper. Acta Mater. 2012; 60:4575–4585. doi: 10.1016/j.actamat.2012.01.038
6.
LuDPWangJZengWJStudy on high-strength and high-conductivity Cu–Fe–P alloys. Mater Sci Eng A. 2006; 421(1–2):254–259. doi: 10.1016/j.msea.2006.01.068
7.
GaoHYWangJShuDEffect of Ag on the aging characteristics of Cu–Fe in situ composites Scr. Mater. 2006; 54:1931–1935.
8.
LiuKMLuDPZhouHTEffect of Ag micro-alloying on the microstructure and properties of Cu–14Fe in situ composite. Mater Sci Eng A. 2010; 527:4953–4958. doi: 10.1016/j.msea.2010.04.051
9.
XieZXGaoHYWangJEffect of homogenization treatment on microstructure and properties for Cu–Fe–Ag in situ composites. Mater Sci Eng A. 2011; 529:388–392. doi: 10.1016/j.msea.2011.09.047
10.
SpitzigWAChumbleyLSVerhoevenJD.Effect of temperature on the strength and conductivity of a deformation processed Cu-20%Fe composite. J Mater Sci. 1992; 27:2005–2011. doi: 10.1007/BF01117911
11.
GoS. YSStrengthening in deformation-processed Cu-20% Fe composites. J Mater Sci. 1991; 26:163–171. doi: 10.1007/BF00576047
12.
SongJSHongSIKimHS.Heavily drawn Cu–Fe–agand Cu–Fe–Cr microcomposites. J Mater Process Technol. 2001; 113:610–616. doi: 10.1016/S0924-0136(01)00665-3
13.
WuZWChenYMengL.Microstructure and properties of Cu–Fe microcomposites with prior homogenizing treatments. J Alloy Compd. 2009; 481:236–240. doi: 10.1016/j.jallcom.2009.03.078
14.
GaoHYWangJShuDMicrostructure and properties of Cu–11Fe–6Ag in situ composite after thermo-mechanical treatments. J Alloy Compd. 2007; 438:268–273. doi: 10.1016/j.jallcom.2006.08.027
15.
ZhangC JTMaJKStudy of high-strength and high-conductivity Cu–Sn–Fe alloys. Mater Sci Poland. 2016; 34:142–147. doi: 10.1515/msp-2016-0015
16.
HallbergH.Approaches to modeling of recrystallization. Metals (Basel). 2011; 1(1):16–48. doi: 10.3390/met1010016
17.
LüYMolodovDAGottsteinG.Recrystallization kinetics and microstructure evolution during annealing of a cold-rolled Fe-Mn-C alloy. Acta Mater. 2011; 59(8):3229–3243. doi: 10.1016/j.actamat.2011.01.063
18.
KaluPNWaryobaDR.A JMAK-microhardness model for quantifying the kinetics of restoration mechanisms in inhomogeneous microstructure. Mater Sci Eng A. 2007; 464(1–2):68–75. doi: 10.1016/j.msea.2007.01.124
19.
FieldDPBradfordLTNowellMMThe role of annealing twins during recrystallization of Cu. Acta Mater. 2007; 55(12):4233–4241. doi: 10.1016/j.actamat.2007.03.021
20.
ChenSPHanlonDNVan der ZwaagS.Quantification of the recrystallization behavior in Al-alloy AA1050. J Mater Sci. 2002; 37(5):989–995. doi: 10.1023/A:1014356116058
21.
GoetzRLSeethenamanV.Modeling dynamic recrystallization using cellular automata. Scripta Mater. 1998; 38(3):405–413. doi: 10.1016/S1359-6462(97)00500-9
22.
GourdetSMontheilletF.A model of continuous dynamic recrystallization. Acta Mater Acta Mater2003; 51:2685–2699. doi: 10.1016/S1359-6454(03)00078-8
23.
HuangKLogéRE.A review of dynamic recrystallization phenomena in metallic materials. Mater Des. 2016; 111:548–574. doi: 10.1016/j.matdes.2016.09.012
24.
UekiMHorieSNakamuraT.Factors affecting dynamic recrystallization of metals and alloys. Mater Sci Tech. 1987; 3:329–337. doi: 10.1179/mst.1987.3.5.329
25.
LiuFYangGC.Stress-induced recrystallization mechanism for grain refinement in highly undercooled superalloy. J Cryst Growth. 2001; 231:295–305. doi: 10.1016/S0022-0248(01)01438-5
26.
ZhaoDMDongQMLiuPAging behavior of Cu–Ni–Si alloy. Mater Sci Eng A. 2003; 361:93–99. doi: 10.1016/S0921-5093(03)00496-9
27.
ZuikoIKaibyshevR.Aging behavior of an Al-Cu-Mg alloy. J Alloy Compd. 2018; 759:108–119. doi: 10.1016/j.jallcom.2018.05.053
28.
LuYMaRWangYN.Annealing behaviour of cold-rolled Cu–Ag alloy under mechanical loads. Mater Sci Tech. 2018; 34:862–868. doi: 10.1080/02670836.2017.1412006
29.
TianKTianBHZhangYAging strengthening mechanism of the Cu-1.0Zr alloy. Metall Mater Trans A. 2017; 48A:5628–5634. doi: 10.1007/s11661-017-4292-6
30.
HuangFXMaJSNingHLPrecipitation in Cu–Ni–Si–Zn alloy for lead frame. Mater Lett. 2003; 57:2135–2139. doi: 10.1016/S0167-577X(02)01212-0
31.
DumanskaMTZiebaPPawloskiAPractical aspects of discontinuous precipitation and dissolution. Mater Chem Phys. 2003; 80:476–481. doi: 10.1016/S0254-0584(02)00550-3
32.
GaoLQYangXZhangXFAging behavior and phase transformation of the Cu-0.2 wt-%Zr-0.15 wt-%Y alloy. Vacuum. 2019; 159:367–373. doi: 10.1016/j.vacuum.2018.10.054
33.
LockyerSANobleFW.Precipitate structure in a Cu-Ni-Si alloy. J Mater Sci. 1994; 29:218–226. doi: 10.1007/BF00356596
34.
SuJHLiuPLiHJPhase transformation in Cu–Cr–Zr–Mg alloy. Mater Lett. 2007; 61:4963–4966. doi: 10.1016/j.matlet.2007.03.085
35.
LeiQLiZPanZYDynamics of phase transformation of Cu-Ni-Si alloy with super-high strength and high conductivity during aging. T Nonferr Metal Soc. 2010; 20:1006–1011. doi: 10.1016/S1003-6326(09)60249-1
