The short tungsten fibre reinforced Zr41.2Ti13.8Ni10.0Cu12.5Be22.5 bulk metallic glass composites with macroscopic isotropic mechanical properties were prepared by infiltration and rapid solidification. The diameters of the tungsten fibres are 300, 500 and 700 µm with a length of 1000 µm and the fibre volume fraction in three kinds of composites is between 60 and 65%. The room temperature compressive deformation behaviours of these composites were investigated systematically. The results show that the strength and plasticity of the composites increase with the decrease in the tungsten fibre diameter. The maximum compressive strength and plastic strain of the composite with 300 µm fibre, respectively, reach 3079 MPa and 37%. The fracture modes of all the composites are shear fracture. The superior compressive property of the composites with short tungsten fibre is due to the competition among different fracture modes and the inhibition effect of the interface on the shear band extension.
SunJ, LuoJ, WangB, Mechanical and corrosion behaviour of in situ intermetallic phases reinforced Mg-based glass composite. Mater Sci Tech Lond. 2017;33:1186–1191. doi: 10.1080/02670836.2016.1271934
3.
PanY, ZhangL, PiJ.Fabrication of Cu rich bulk metallic glass composites via solidification method. Mater Sci Tech Lond. 2014;30:166–170. doi: 10.1179/1743284713Y.0000000329
HaysCC, KimCP, JohnsonWL.Microstructure controlled shear band pattern formation and enhanced plasticity of bulk metallic glasses containing in situ formed ductile phase dendrite dispersions. Phys Rev Lett. 2000;84:2901–2904. doi: 10.1103/PhysRevLett.84.2901
6.
QiaoJW, SunAC, HuangEW, Tensile deformation micromechanisms for bulk metallic glass matrix composites: from work-hardening to softening. Acta Mater. 2011;59:4126–4137. doi: 10.1016/j.actamat.2011.03.036
7.
ZhangB, LiH, ZhuZW, Reaction induced anomalous temperature dependence of equilibrium contact angle of TiZr based glass forming melt on Al2O3 substrate. Mater Sci Tech Lond. 2013;29:332–336. doi: 10.1179/1743284712Y.0000000153
8.
DingS, KongJ, SchroersJ.Wetting of bulk metallic glass forming liquids on metals and ceramics. J Appl Phys. 2011;110, 043508-043501-043508-043506.
KhademianN, GholamipourR.Fabrication and mechanical properties of a tungsten wire reinforced Cu-Zr-Al bulk metallic glass composite. Mater Sci Eng A. 2010;527:3079–3084. doi: 10.1016/j.msea.2010.01.086
11.
ClausenB, LeeSY, ÜstündagE, Compressive yielding of tungsten fiber reinforced bulk metallic glass composites. Scripta Mater. 2003;49:123–128. doi: 10.1016/S1359-6462(03)00237-9
12.
WangG, ChenDM, ShenJ, Deformation behaviors of a tungsten-wire/bulk metallic glass matrix composite in a wide strain rate range. J Non Cryst Solids. 2006;352:3872–3878. doi: 10.1016/j.jnoncrysol.2006.06.037
13.
ConnerRD, DandlikerRB, ScruggsV, Dynamic deformation behavior of tungsten-fiber/metallic-glass matrix composites. Int J Impact Eng. 2000;24:435–444. doi: 10.1016/S0734-743X(99)00176-1
14.
Choi-YimH, ConnerRD, SzuecsF, Quasistatic and dynamic deformation of tungsten reinforced Zr57Nb5Al10Cu15.4Ni12.6 bulk metallic glass matrix composites. Scripta Mater. 2001;45:1039–1045. doi: 10.1016/S1359-6462(01)01134-4
15.
ZhangB, FuH, LiZ, Anisotropic tensile properties of tungsten fiber reinforced Zr based metallic glass composites. Mater Sci Eng A. 2014;619:165–170. doi: 10.1016/j.msea.2014.09.084
16.
ZhangB, FuH, ShaP, Anisotropic compressive deformation behaviors of tungsten fiber reinforced Zr-based metallic glass composites. Mater Sci Eng A. 2013;566:16–21. doi: 10.1016/j.msea.2012.12.080
17.
ChenJH, ChenY, JiangMQ, On the compressive failure of tungsten fiber reinforced Zr-based bulk metallic glass composite. Int J Solids Struct. 2015;69–70:428–441. doi: 10.1016/j.ijsolstr.2015.05.008
18.
ZhangZF, EckertJ, SchultzL.Difference in compressive and tensile fracture mechanisms of Zr59Cu20Al10Ni8Ti3 bulk metallic glass. Acta Mater. 2003;51:1167–1179. doi: 10.1016/S1359-6454(02)00521-9
19.
ZhangZ, HeG, ZhangH, Rotation mechanism of shear fracture induced by high plasticity in Ti-based nano-structured composites containing ductile dendrites. Scripta Mater. 2005;52:945–949. doi: 10.1016/j.scriptamat.2004.12.014
20.
LeamyHJ, WangTT, ChenHS.Plastic flow and fracture of metallic glass. Metall Mater Trans B. 1972;3:699–708. doi: 10.1007/BF02642754
21.
LewandowskiJJ, GreerAL.Temperature rise at shear bands in metallic glasses. Nat Mater. 2006;5:15–18. doi: 10.1038/nmat1536
22.
ZhangH, ZhangZF, WangZG, Effects of tungsten fiber on failure mode of Zr-based bulk metallic glassy composite. Metall Mater Trans A. 2006;37:2459–2469. doi: 10.1007/BF02586219
