The effect of the Al content on the microstructure and mechanical behaviour of Mg–8Li–xAl–0.5Ca alloys is investigated. The experimental results show that an as-cast Mg–8Li–0.5Ca alloy is mainly composed of α-Mg, β-Li and granular Mg2Ca phases. With the addition of Al, the amount of α-Mg phase first increases and then decreases. In addition, the intermetallic compounds also obviously change. The microstructure of the test alloys is refined due to dynamic recrystallisation that occurs during extrusion. The mechanical properties of extruded alloys are much more desirable than the properties of as-cast alloys. The as-extruded Mg–8Li–6Al–0.5Ca alloy exhibits good comprehensive mechanical properties with an ultimate tensile strength of 251.2 MPa, a yield strength of 220.6 MPa and an elongation of 23.5%.
LiJ, QuZ, WuR, Effects of Cu addition on the microstructure and hardness of Mg–5Li–3Al–2Zn alloy. Mater Sci Eng A. 2010;527(10–11):2780–2783. doi: 10.1016/j.msea.2010.01.021
2.
MahmudiR, ShalbafiM, KaramiM, Effect of Li content on the indentation creep characteristics of cast Mg–Li–Zn alloys. Mater Des. 2015;75:184–190. doi: 10.1016/j.matdes.2015.03.003
3.
TsaiMS, ChangCP.Grain size effect on deformation twinning in Mg–Al–Zn alloy. Mater Sci Technol. 2013;29:759–763. doi: 10.1179/1743284713Y.0000000237
4.
MahataA, SikdarK.Molecular dynamics simulation of nanometer scale mechanical properties of hexagonal MgLi alloy. J Magnes Alloys. 2016;4(1):36–43. doi: 10.1016/j.jma.2015.12.001
5.
MahataA, SikdarK.Molecular dynamics simulation of nanometer scale mechanical properties of hexagonal Mg Li alloy. J Magnes Alloys. 2016;4(1):36–43. doi: 10.1016/j.jma.2015.12.001
6.
YangY, PengX, WenH, Influence of extrusion on the microstructure and mechanical behavior of Mg-9Li-3Al-xSr alloys. Metall Mater Trans A. 2012;44(2):1101–1113. doi: 10.1007/s11661-012-1441-9
7.
ZouY, ZhangL, LiY, Improvement of mechanical behaviors of a superlight Mg-Li base alloy by duplex phases and fine precipitates. J Alloys Compd. 2018;735:2625–2633. doi: 10.1016/j.jallcom.2017.12.025
8.
KangZX, LinK, ZhangJY.Characterisation of Mg–Li alloy processed by solution treatment and large strain rolling. Mater Sci Technol. 2016;32:1743284715Y. doi: 10.1179/1743284715Y.0000000119
9.
ZhaoJ, LiZ, LiuW, Influence of heat treatment on microstructure and mechanical properties of as-cast Mg–8Li–3Al–2Zn– x Y alloy with duplex structure. Mater Sci Eng A. 2016;669:87–94. doi: 10.1016/j.msea.2016.05.085
10.
ZhangJ, XuM, TengX, Effect of Gd addition on microstructure and corrosion behaviors of Mg–Zn–Y alloy. J Magnes Alloys. 2016;4(4):319–325. doi: 10.1016/j.jma.2016.09.003
11.
GolmakaniyoonS, MahmudiR.Microstructure and creep behavior of the rare-earth doped Mg–6Zn–3Cu cast alloy. Mater Sci Eng A. 2011;528(3):1668–1677. doi: 10.1016/j.msea.2010.10.095
12.
NinomiyaR, OjiroT, KubotaK.Improved heat resistance of Mg-Al alloys by the Ca addition. Acta Metall Mater. 1995;43(2):669–674. doi: 10.1016/0956-7151(94)00269-N
13.
WangF, SunSJ, BoYU, First principles investigation of binary intermetallics in Mg-Al-Ca-Sn alloy: stability, electronic structures, elastic properties and thermodynamic properties. Trans Nonferr Met Soc China. 2016;26(1):203–212. doi: 10.1016/S1003-6326(16)64107-9
14.
ZhouY-L, LiY, LuoD-M, Microstructures, mechanical properties and in vitro corrosion behaviour of biodegradable Mg–Zr–Ca alloys. J Mater Sci. 2012;48(4):1632–1639. doi: 10.1007/s10853-012-6920-2
15.
LipingB, YuyueZ, GuangC, Formation of eutectic structure in Mg-9Li-0.5Ca alloy and Its mechanical behavior. Rare Met Mater Eng. 2017;46(1):266–269.
16.
KimJH, KimYH, YooHS, . Effects of Zn and Ca additions on microstructure and mechanical properties of Mg-11Li based alloys. Journal of Nanoscience & Nanotechnology. 2016;16(1-2):11233–11237. doi: 10.1166/jnn.2016.13484
17.
WangT, WuR, ZhangM, Effects of calcium on the microstructures and tensile properties of Mg–5Li–3Al alloys. Mater Sci Eng A. 2011;528(18):5678–5684. doi: 10.1016/j.msea.2011.04.034
18.
ZhaM, ZhangH-M, WangC, Prominent role of a high volume fraction of Mg 17 Al 12 particles on tensile behaviors of rolled Mg–Al–Zn alloys. J Alloys Compd. 2017;728:682–693. doi: 10.1016/j.jallcom.2017.08.289
19.
YinH, LiuZ, LiuX, Effects of Al addition on the microstructure and mechanical properties of Mg–4Y alloys. Mater Sci Technol. 2017;33(18):1–9. doi: 10.1080/02670836.2017.1353664
20.
PengQZ, ZhouHT, ZhongFH, Effects of homogenization treatment on the microstructure and mechanical properties of Mg–8Li–3Al–Y alloy. Mater Des. 2015;66:566–574. doi: 10.1016/j.matdes.2014.03.046
21.
JiangZ, JiangB, YangH, Influence of the Al 2 Ca phase on microstructure and mechanical properties of Mg–Al–Ca alloys. J Alloys Compd. 2015;647:357–363. doi: 10.1016/j.jallcom.2015.06.060
22.
KondoriB, MahmudiR.Effect of Ca additions on the microstructure, thermal stability and mechanical properties of a cast AM60 magnesium alloy. Mater Sci Eng A. 2010;527(7–8):2014–2021. doi: 10.1016/j.msea.2009.11.043
23.
QuZ, WuR, ZhanH, The solution and room temperature aging behavior of Mg–9Li–xAl(x=3, 6) alloys. J Alloys Compd. 2012;536:145–149. doi: 10.1016/j.jallcom.2012.05.021
24.
LiuH, ChenY, TangY, The microstructure and mechanical properties of permanent-mould cast Mg–5wt%Sn–(0–2.6)wt%Di alloys. Mater Sci Eng A. 2006;437:348–355. doi: 10.1016/j.msea.2006.07.149
25.
GaoL, XueS, ZhangL, Effects of trace rare earth Nd addition on microstructure and properties of SnAgCu solder. J Mater Sci Mater Electron. 2010;21:643–648. doi: 10.1007/s10854-009-9970-8
26.
FuX, YangY, HuJ, Microstructure and mechanical properties of as-cast and extruded Mg-8Li-1Al-0.5Sn alloy. Mater Sci Eng A. 2017;709:247–253. doi: 10.1016/j.msea.2017.10.036
27.
LiM, HaoH, ZhangA, Effects of Nd on microstructure and mechanical properties of as-cast Mg-8Li-3Al alloy. J Rare Earth. 2012;30:492–496. doi: 10.1016/S1002-0721(12)60078-7
28.
LiuCM, ZhuXR, ZhouHT.Magnesium alloy phase graph set. Changsha: Central South University Press; 2006.
29.
WuL, CuiC, WuR, Effects of Ce-rich RE additions and heat treatment on the microstructure and tensile properties of Mg–Li–Al–Zn-based alloy. Mater Sci Eng A. 2011;528(4–5):2174–2179. doi: 10.1016/j.msea.2010.11.063
30.
KimWJ, MoonIK, HanSH.Ultrafine-grained Mg–Zn–Zr alloy with high strength and high-strain-rate superplasticity. Mater Sci Eng A. 2012;538:374–385. doi: 10.1016/j.msea.2012.01.063
31.
YongQ.The second phase in steels. Beijing: Metallurgical Industry Press; 2006. pp. 147–190.
32.
ParkSH, JungJ-G, YoonJ, Influence of Sn addition on the microstructure and mechanical properties of extruded Mg–8Al–2Zn alloy. Mater Sci Eng A. 2015;626:128–135. doi: 10.1016/j.msea.2014.12.039
